Use of Quarry Dust to Replace Sand in Concrete – An Experimental Study329 Кб. For this concrete mix, quarry dust was added for replacement of sand from 0% to in step of 10%. www.ijsrp.org International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 ISSN 2250-3153 2 B...Inquiry Online Contact Us
Samples of concrete (cubes and cylinders) for one mix, namely 1:1.02:2.22 were made using quarry dust and marble powder as fine aggregate in concrete. INTRODUCTION Currently the world is poised for a major initiative infrastructure development in construction of buildings and other structures where concrete plays a vital role in this initiative ...
construction work. Quarry dust is produced from crusher unit and each crusher unit is produced nearly 22% to 27% of dust. This dust is completely waste material for crusher unit but quarry dust is useful for construction work as sand. If we mix quarry dust in sand then only 65% to 75% of sand replaced by quarry dust because strength of concrete is
Jul 07, 2020 The comparable strength property was obtained for an aggregate made of 37.5% quarry dust and 62.5% activated fly ash. Hence, the aggregates with this proportion were used to prepare the concrete specimens. The concrete was cast by varying the coarse aggregate replacement ratio of 0%, 25%, 50%, 75%, and 100%.
For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of 10%. International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 2
The paper describe the role of quarry dust In the construction of buildings and other structures to eliminate the demand of natural sand by using quarry waste to replace the use of natural sand. We are investigating the potential of using quarry
-The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such materials.
the title of the work and journal citation in the form of a proper scientific referencing. PROPERTIES OF MICRO FINE QUARRY DUST CONCRETE NUR HANANI ABDUL RAHIM1*, KARTINI KAMARUDDIN2, HAMIDAH MOHD SAMAN3 1, 2, 3 Universiti Teknologi MARA (UiTM), Shah Alam, Selangor, Malaysia Index Terms Micro Fine Quarry Dust Cement Replacement Compressive Strength
Jun 06, 2016 Quarry dust a by- product from crushing process during quarrying activities is good alternative during construction projects. It is used as substitute to sand to make quarry dust concrete which is believed to be stronger and more durable than the regular concrete materials. Uses of Quarry Dust. It can be used as substitute to sand wholly or partly.
found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days. II.
Quarry dust can be utilized in concrete m ixtures as a good substitute for natural river sand giving higher strength at 50 % replacement (Balamurgan et al ., 2013).
Sep 10, 2020 A. Ma, S.I. Abba, N. Mm, Strength and Durability of Concrete Containing Quarry Dust as Partial Replacement of Cement Ma’aruf A 1 , S I Abba 2 and Nuruddeen MM, European Journal of Advances in Engineering and Technology. 4 (2017) 273–281. www.ejaet.com.
ABSTRACT-The purpose of this work is to describe the effect of quarry dust and dolomite on the compressive strength of concrete. The present examinations indicate that dolomite may be used as partial replacement of cement in concrete and quarry dust may be suitably replaced with fine aggregate in concrete to some extent.
Concrete technology by Ms. SHETTY. and IS 456:2000. S.Subhashini on “use of quarry dust in concrete design”.(2016) Praveen M (Feb 2014) Bijapur: Recent Trends in Replacement of Natural Sand With Different Alternatives’’(IOSR-JMCE) e-ISSN: 2278-1684, pISSN: 2320-334X PP 59-6
1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3. From the above results 15% replacement of quarry dust gives high Compressive and Flexural Strength. 4. By using quarry dust wastes instead of conventional
This study aims to assess the production of cellular micro-concrete, consisting of quarry dust, calcareous fly ash, cement, and aluminum powder as aerating agent. The proposed mixture design methodology is based on a Box–Behnken fractional factorial experimental design. Testing of specimens included compressive and flexural strength, density, water absorption, and thermal conductivity ...
concrete with quarry dust as fine aggregate. Keywords: Concrete, Fine aggregate, Quarry dust, River sand, Compressive strength, Shrinkage, Workability. 1. Introduction Concrete is one of the most widely used building materials in construction. It is a composite building material made of cement/binder and ...
Quarry Process. Quarry process, also known as QP, dense grade aggregate (DGA), crusher run and road stone, is a combination of small, 3/4-inch-or-less crushed stone and stone dust. Most often it is made out of crushed limestone, granite-gneiss, trap rock or a combination of the aforementioned.
of fine aggregate with stone dust. The results shows strength of concrete increases within 5-12 percent up to 50 percent replacement of fine aggregate. And at 60 percent stone dust in concrete the maximum value of compressive strength is obtained which is 17 percent more than referral concrete (concrete with zero percent stone dust).
quarry dust is reduced by the addition fly ash. This paper investigates the workability and strength characteristics of Quarry Dust Concrete (QDC) containing 0% to 30% of fly ash. Based on the test results, it can be concluded that combined use of quarry dust and fly ash can be shown improved strength in concrete and also
inhibitors in concrete containing quarry dust as fine aggregate,”Journal of Engineering and Applied Sciences, vol. 6, no. 11, pp. 124–135, 2011.  R. P. Nanda, A. K. Das, and N. Moharana, “Stone crusher dust as a fine aggregate in concrete for paving blocks,” International Journal of Civil and Structural Engineering, vol.
Dec 12, 2017 Dr. D. V. Prasada Rao, C. S. Mallikarjuna, An Experimental Investigation on Properties of Concrete by Partial Replacement of Cement with GGBS and Fine Aggregate with Quarry Dust , International Journal of Science and Research (IJSR), https://www.ijsr.net/search_index_results_paperid.php?id=ART20178797, Volume 6 Issue 12, …
The lightweight aggregate is an aggregate that weighs less than the usual rock aggregate and the quarry dust is a rock particle used in the concrete for the experimentation. The significant intention of the proposed technique is to frame a mathematical modeling with the aid of the optimization techniques. The mathematical modeling is done by minimizing the cost and time consumed in the case of ...
2.1 Quarry rock dust: The Quarry Rock Dust obtained from local resource Sri Kanaka Durga Fal-G Brick products, Visakhapatnam was used in concrete to cast test cubes and beams. The physical and chemical properties of Quarry Rock Dust obtained by testing the samples as per Indian Standards are listed in Tables 1 and 2, respectively.
Title: Investigating Strength Properties of Geopolymer Concrete with Quarry Dust Author(s): A. Muthadhi and V. Dhivya Publication: Materials Journal Volume: 114 Issue: 3 Appears on pages(s): 355-363 Keywords: Class C fly ash; compressive strength; geopolymer concrete; quarry dust Date: 5/1/2017 Abstract: To address the environmental constraints due to cement production and sand scarcity ...
International Journal of Engineering Trends and Applications (IJETA) – Volume 5 Issue 3, May-Jun 2018 ISSN: 2393-9516 www.ijetajournal.org Page 57 Partial Replacement of Fine Aggregates with Quarry Dust and Marble Powder in Concrete
Copyright © 2020 Heavy Baylin Machinery Company All rights reserved